Boilers vs. Heat Pumps

boiler vs heat pump - Twin Cities

Boiler vs. Heat Pump

With the growing popularity of renewable energy sources, the use of non-traditional heating systems has also shown an increasing interest for homeowners. The reasoning behind the current increase in popularity of heat pumps, solar panels, and boilers depends on cost-effectiveness. Even some would like to assume that some heating systems are better than others. So, what’s the better choice? In the article below, McQuillan Bros, a St. Paul plumbing and heating company, shares the differences between boilers vs. heat pumps in your Twin City home.

 

Boilers

Boilers are commonly found in older homes. You can think of a boiler as a sealed chamber that is heated to a particular temperature. Combined, this is used to produce heat and provide hot water. If you are searching for a boiler, you may want to consider the following technical criteria that will help the customer compare the boilers easily and pick the one that best suits his/her needs and budget.

boiler vs heat pump - Twin Cities

Boiler Pump Features to Consider:

  • The performance of the power (rated power)
  • The rate of efficiency (COP)
  • Form of coolant to be used
  • The working temperature of the coolant
  • The operating pressure of the coolant
  • Hydraulic Power
  • We will not avoid explaining each of the technical criteria as it does not serve the intent of this blog post, but we invite you to take a close look at the sections on boilers and other renewable energy technologies on our website.

Types of Boilers

  • Boilers for Biomass
  • Wood Pellet Boiler
  • Boiler condensation
  • Combi Boiler
  • Electrical boilers
  • Carbon (Conventional) Boiler
  • Thermal pumps

The heat pump is a more complicated system compared to the boiler, but the main purpose behind the operation of the pump is more or less the same. The function of the heat pump is based on the absorption and transfer of thermal energy (high to low).

Most heat pumps use a liquid refrigerant as a coolant, which is pumped through underground pipes or through an external ventilator cover tube. This absorbs air or underground heat, which is later passed through a compressor, then further heated.

Heat Pump Features to Consider: 

  • Initial installation cost
  • The refrigerant pump
  • The size of the pump (BTU-British Thermal Unit)
  • Functional characteristics of the pump-SEER Rating (seasonal energy efficiency ratio) and HSPF Rating (heating seasonal performance factor)
  • The warranty terms of the pump

Types of Heat Pumps

  • Air Source Heat Pump
  • Ground Source Heat Pump
  • Water Source Heat Pump
  • Air to Water Heat Pump
“McQuillan installed a boiler and water heater in my new home. They also charged my mini Split system. They did a great job. Everything looks very nice. The guys are kind, professional, experienced.” – Michael B. 

Which is better: Heat pump vs. boiler?

So, which is better for your home? As has already been demonstrated, the heat pump is an absolute champion when it comes to CO2 emissions and can produce a higher efficiency rate compared to the boiler. It should be noted, however, that while the ground or air source heat pump has a COP (Coefficient of Performance) of around 3, which surpasses the electric boiler and the oil boiler. If you’re wanting to reduce costs and emissions, know that the heat pump does not outperform the gas boiler. 

Additionally, the high initial costs and the limited heating output of the heat pump, having a gas boiler could prove cheaper. Our friends at Gilmore Heating, Air, and Plumbing, a heating company in Placerville, agree that to a certain extent, a heat pump is more effective, particularly during the cold days of winter, when you may need a higher heat output. 

Considering the continuous development of heat pumps, we would expect them to increase their output rate in the near future and thus set higher efficiency requirements that will be difficult to achieve with other heating devices available on the market. 

Countries worldwide are making the transition to low-carbon solutions for residential and commercial use. With the rise of hybrid systems, you might want to consider a boiler over a heat pump. Everyone’s home is different, and most of us don’t have the initial choice of having a heat pump or a boiler. Heat pumps are becoming increasingly popular, but just like anything else, there are pros and cons. 

Ask a Professional Plumber 

If you can’t decide whether or not you need a heat pump or boiler installationcontact McQuillan Bros. Our plumbing contractors in Twin Cities, MN, have been proudly serving the community since 1883. We’re happy to weigh the pros and cons with you and help you decide which heating system is best for your home. Give us a call today for a free estimate on HVAC services.

How to Save Energy This Winter

How to Save Energy This Winter - Twin Cities MN

How to Save Energy This Winter 

If you’ve heard of the term “heat or eat,” you may also know that many people have a very real problem when temperatures are falling at this time of year. Energy bills are known to rise this time of year, which can be a financial burden for some. The good news is that there are ways to keep your energy levels low. In the article, our HVAC company in Minneapolis, MN, shares how to save energy this winter.

Deal with Draughts 

Gaps in your doors, windows, and floors will let cool air in and warm air out. So consider mounting the drag excluders on your doors and windows. You may use an appropriate sealant, insulating strips, wooden beads, or even paper pieces. Rolled-up blankets make excellent draught excluders under your doors, too. 

Floors with holes and cracks are also responsible for heat loss, so check your floors carefully and consider getting any gaps sealed with a silicone-based sealant. Look out for other areas that can also be left in cold air. But never cover air vents, as the air vent may increase the risk of carbon monoxide poisoning.

In the meantime, if your windows are not double-glazed, it’s a good idea to close your curtains, blinds, or shutters when the sun sets-but leave them open throughout the day as the sun shines through your windows will help your room stay warm.

How to Save Energy This Winter - Twin Cities MN

 

 

 

Avoid Leaving Devices On

Try not to leave electrical equipment such as TVs, DVD players, laptop boxes, cell phone chargers, and other standby appliances. If they’re on standby, they’re still turned on, which means they’re wasting their resources instead of leaving them on standby, switching them off completely. Our friends at Specialized AV, a Norcal audio and video company, adds that there are plenty of smart home automation systems that will help you save time and money.

Insulate Your Home

There are substantial energy savings to be made if your home is well-insulated. For example, experts say that about a quarter of the heat from homes goes straight out of a roof with no proper insulation. You can insulate your roof, cavity walls, and even solid walls, and even place insulation under your floorboards, all of which can contribute to lower energy bills as well as a warmer home climate.

Depending on the type of water heater you have, you might also want to insulate your hot water tank and pipes, which will help keep your water cooler for a longer period of time. You can get relatively inexpensive foam tubes to cover the pipes between your hot water tank and the boiler.

Keep Heating Under Control

Installing a thermostat, timer, and thermostatic radiator valve can help you save also. This ensures that you can configure the timer to switch your heating on before you get up or before you get home, which saves more energy compared to turning your thermostat up to warm up your home instantly. Individual thermostat valves on your radiators will also give you control over which rooms you want to heat and which temperature you want to heat.

Bleeding your radiator might be helpful as well since trapped air in the radiators will make them hotter and less effective. Plus, try not to position the furniture directly in front of the radiators, as it might mean that the heat will be absorbed into the furniture rather than heat the air.

Our Minneapolis HVAC techs highly recommend smart heating controls. These are the latest technologies that help you monitor your heating remotely through your smart device.

Heat Check Twin Cities MN

Turn Your Thermostat Down

Reducing your room temperature by just 1° could reduce your heating bills by up to 10%. If you’re healthy and under 65, you can comfortably get your home cooler than 65°F if you’re relaxed. Otherwise, heat your home to at least 65°F.

You will also want to turn the thermostat down on your water heater tank, as it saves both water and power, so you don’t need too much cold water to keep the temperature of your bath or shower warm.

Switch to LED Bulbs

Replacing all of your light bulbs with energy-saving LED bulbs might be an expense, but it’s worth it. Many LED light-bulbs are rated life of up to 50,000 hours, which means that if you use them 12 hours a day, they will last more than 11 years. LED bulbs often use less energy than other bulbs.

An average household will spend $134, replacing all its LED bulbs. But that will save about $47 a year on expenses. So if you’re not replacing them for 11 years, you’re going to save a huge amount. Although LED is still a relatively new lighting technology, the prices have fallen. Find them in your nearest supermarket or DIY shop.

Often strive to get into the habit of turning off the lights when you don’t need them. Switching off the light for just a few seconds saves more energy than it takes for the light to start up again, no matter what sort of bulb you use. This will save you about $19 on your annual energy bill.

Service Your Home’s Boiler

If your Minneapolis home has gas or oil central heating, try to ensure that your boiler is serviced every year by a professional heating company in Minneapolis, MN. If, on the other hand, your boiler is getting old, it could be worth replacing it with a more powerful one that could save you money in the long run and keep your home warm. New boilers are expensive-usually around $3,000. 

If you’re concerned about how to save energy this winter, contact McQuillan Bros. One of our HVAC techs will examine your heating and cooling systems and plumbing to see if there are ways to improve. If you’re looking to save on HVAC repairs or plumbing repairs, check out our coupons and special offers

Contact an expert

We Can't Wait To Serve You!

Complete the form below and one of our team members will give you a call to help get you scheduled. If you have an urgent need please call us at
(651) 243-4002

Furnace Won’t Turn On: What to Do

Furnace Won't Turn On: Here's What to Do!

Furnace won’t turn on? As a Minneapolis homeowner, a broken furnace during winter may seem like the end of the world.  Don’t try to survive all season without a furnace. Contact a heating and cooling company in St. Paul for furnace repair. In the meantime, here’s what to do if your furnace won’t turn on.

Your Furnace is Not Receiving Power 

This is a common problem with most furnaces. The good thing is that it is easy to identify and fix. The electric input in your furnace could be damaged or tampered with causing this problem. 

To determine whether the furnace is not receiving power, you can check other appliances in your house. If they can turn on, then your furnace is likely not receiving power. 

Check the circuit breaker and make sure that it is not switched off. Your furnace will have its own circuit breaker. Check whether it is on or off. If it is off, push it to the on position- but only once. The circuit breaker is supposed to switch off in the event there is a fault along with the power systems. If it switches off after you turn it on, call for furnace repair services in St. Paul, MN. 

Furnace Won't Turn On - furnace repair St Paul MN

The Float Switch is Up 

A float switch is a sensor that monitors the level of condensate within your furnace. Remember, your furnace burns fuel to warm you up. This burning produces condensate which cools and collects as water within the furnace in a place called the condensate pan. 

As it accumulates, it lifts the float switch. This collected water is then drained by a condensation pump because it is usually acidic.

Therefore, if the float switch is up, it could mean that the condensation pump is not working correctly. Check if the drain is clear. If it is not, clear is so that the collected water can drain and the float switch can drop. 

Clogged Air Filter 

Your air filter prevents dust and debris from being blown into your house. With time, the air filter will accumulate excess dust and clog. Once clogged the furnace will turn off to prevent overheating. 

The air filter should be changed frequently to prevent these issues and to keep your furnace running. 

Your Thermostat is Acting Up 

Your thermostat is important to your furnace. It allows the furnace to turn on automatically once a certain threshold is met. Usually, you will have set this threshold. 

Sometimes, thermostats misbehave and lose their programming, explains our friends at Gilmore Heating, Air, & Plumbing, a heating company in Folsom. This makes the reset to their default settings. If this is the case, a simple reset will have your house warmed up again in no time. If you are not sure whether this is the issue, set the thermostat temperatures at 10 degrees hotter than the ambient temperature and observe. 

The Blower Motor is Not Working 

The blower motor blows hot air through the vents when your furnace is on. You can easily tell whether your blower motor is working by looking at your furnace. Usually, there is a small window on the side of your furnace. 

If you look through it, you should see a blinking green light. This is the blower motor. Check whether the light is blinking, if not, call for a furnace repair service company

Keep your House Warm All the Time 

Staying warm throughout is a matter of making sure that your furnace is in its best condition. Contact McQuillan Bros and enjoy the best furnace inspection and repair services throughout the year.

Contact an expert

We Can't Wait To Serve You!

Complete the form below and one of our team members will give you a call to help get you scheduled. If you have an urgent need please call us at
(651) 243-4002

Common Heat Pump Problems and Solutions

common heat pump problems and solutions - McQuillan Bros St Paul

Common Heat Pump Problems & Solutions

If you’re living in Northern USA, chances are you have a heat pump for when it gets cold. Generally, heat pumps are mechanical or electrical devices that transfer heat from one area to another. Since they work by transferring already existing heat energy instead of generating it, they tend to be the more energy-efficient heating and cooling solution.

 

Heat Pumps

In cold temperatures, the pump will extract the little heat energy outside and transfer it inside. It reverses the process when it’s warm, extracting warm air from the house and dumping it outside. Since heat pumps are powered by electricity and transfer heat instead of generating it, heat pumps are more reliable. 

Heat pumps are known to have a technical issue or two. Basic troubleshooting once every while will enable you to catch potential issues before they become more serious and nip them in the bud. And while plenty of folks know enough to deal with some issues, the best thing to do would be to contact a Vadnais Heights heating contractor to inspect the system. The following are some common heat pump problems and possible solutions.

common heat pump problems and solutions - McQuillan Bros St Paul

Heat Pump Problem: No Warm Air

If you notice that your heat pump is not running and there is no warm air being pumped into the house, don’t panic. The system is most likely not receiving power. Check the circuit breaker to see if it has tripped. If it has, reset it to fix the power supply problem. If that’s not the issue, check if the thermostat is set to the correct setting and make sure it is set to heat, and the heat pump is on. 

You may also be dealing with improper wiring in the thermostat, which ends up frying the electrical components within. This is usually common with new thermostats, but the technician may have made a mistake while wiring it in some cases. Additionally, the thermostat may not be the right model for your heat pump. If none of these fixes apply or some of the wires are frayed, you will have to call a Vadnais Heights HVAC company for a professional assessment.

Heat Pump Problem: The Heat Pump is Constantly Running

If the weather is cold enough, the heat pump may have to run continuously to keep the interior suitably warm. The same may happen during the summer as the heat pump struggles to keep the interior cool. However, if it is relatively warm outside and the heat pump is still running non-stop, there may be an issue. Placerville heating experts, Gilmore Heating & Air, suggest that it may be caused by a dirty coil, which prevents the unit from releasing heat. 

Additionally, grime and dirt may corrode the metal coils and create holes that leak refrigerant. Thus, the unit won’t be able to cool efficiently and will run constantly. You may also have a poorly insulated space that loses too much heat or a frozen outdoor unit. Reach out to a Vadnais Heights HVAC contractor to figure out what’s wrong.

Heat Pump Problem: Insufficient Heating 

In this case, the heat pump is up and running, but the air coming out of the vents is cool. This may be caused by built-up dirt or some other obstruction blocking the airflow, preventing the heat pump from transferring heat into the house. A dirty air filter will also reduce the airflow.

You can avoid that by changing the air filter once every three months or even more frequently, depending on your usage. If you can, check the filter every month and change it if it’s even slightly dirty. Inspect and clean the supply and return registers, fan, and outdoor coils for dirt as well. Additionally, clear any clutter and dirt away from your outdoor unit and ensure the indoor unit isn’t blocked.

Heat Check Twin Cities MN

Heat Pump Problem: The Heat Pump is Blowing Cold Air

Cold air is definitely welcome during the scorching hot days of summer and any other unseasonably warm day. However, if the heat pump is blowing out cold air when it shouldn’t, there may be an issue with the refrigerant charge, compressor, or valve. It may also be that someone switched it to A/C mode or has detected frost and is pumping hot air to the outdoor unit to thaw it out.

If the heat pump is defrosting, you can just wait until it’s done. This usually takes 10-15 minutes. The interior components like coils could be dirty. This can make the system run less efficiently, or there may be dirt or obstructions preventing proper airflow. If that’s not it, try setting the thermostat to emergency heat. If the system warms up after that, the issue may be with the outside unit. If not, the issue probably lies with the thermostat or air handler. 

As you can see, these common heat pump problems can be a challenge. Reaching out to a Vadnais Heights heating and cooling expert will help you figure out what’s wrong with your heat pump and fix it. Are you experiencing any of the described heat pump problems? Don’t let minor issues become expensive headaches down the line. Contact McQuillan Bros today for a complimentary consultation.

Contact an expert

We Can't Wait To Serve You!

Complete the form below and one of our team members will give you a call to help get you scheduled. If you have an urgent need please call us at
(651) 243-4002

Should I Repair or Replace My Furnace?

repair or replace my furnace? - McQuillan Bros

Should I Repair or Replace My Furnace?

Although we are an entire season away from winter, it doesn’t hurt to prepare in advance. It’s never too late to start equipping your home for winter, especially if you are a homeowner in Northern US cities like Minneapolis. One of the most crucial steps of readying your house for the cold is inspecting your furnace for signs of wear and tear. The last thing you want to do is wake up to a freezing cold house in the middle of winter.
However, many people have trouble deciding whether they should keep forking out their money for furnace repairs or just replace the furnace entirely. Ultimately, each case is unique, and the decision to repair or replace varies. Ideally, this decision should be made long before winter starts. This will give you more time to research and ask around for estimates. Also, it’s likely that it will cost you less in parts and labor as there will be less demand for a White Bear Lake HVAC contractor at the time. 
Additionally, you will be able to plan and budget your finances. Below is a guide prepared by the White Bear Lake heating and cooling experts at McQuillan Bros. Use this guide to help you decide between repairing or replacing your furnace.

Your Furnace Is Leaking Carbon Monoxide

Carbon monoxide is an odorless, tasteless, and colorless gas that is fatal if inhaled for extended periods. If your furnace has a cracked combustion chamber and is leaking carbon monoxide, it needs to be replaced ASAP. According to the Centers for Disease Control and Prevention (CDC), over 2,200 people died from unintentional carbon monoxide poisoning between 2010 and 2015. Majority of these deaths happening during winter.
If you notice any of the following, your furnace may be leaking carbon dioxide:

  • Streaks of soot around the furnace.
  • Excess moisture on surfaces like windows and walls.
  • A yellow flame instead of blue in the furnace.
  • Rust on the furnace exhaust pipe.
  • Nausea, disorientation, headache, and other flu-like symptoms. 

Immediately evacuate the building and seek medical attention. Once you have called the fire department and notified your utility company to shut off your gas, contact a White Bear Lake HVAC contractor to replace your furnace.

Your Furnace is Over 15 Years Old

A high-quality furnace should last 15-30 years before being replaced, according to the US Department of Energy. Over time, even the best made and maintained heating systems would start breaking down, working less efficiently, and requiring more repairs. It would be economical to replace an old furnace instead of spending thousands of dollars on repairs. However, if the furnace is relatively young and still has much of its lifespan ahead of it, having it serviced would be the better choice.

The Cost of Repairing the Furnace is Over Half the Cost of Replacing It

It makes basic economic sense, and even the experts recommend it. If the furnace repair cost is more than 50% the cost of a new furnace replace it. An older system that has exceeded around three-quarters or 75% of its life expectancy should be replaced if repairing it is more than a third of the replacement cost.

Your Heating Bills Are Increasing

Aside from the usual fluctuations due to weather patterns, supply, and demand, you should be concerned if you notice unusual spikes in your energy bills. Due to wear and tear and simple aging, the furnace’s internal components start breaking down and work less efficiently. This puts extra strain on the furnace.
To ensure the output remains the same, the furnace will use more energy. So, you end up paying more for the same level of heating. Our friends at Gilmore Heating and Air, a heating and cooling company in Placerville, say that if the furnace is less than 15 years old and the cost of repair is less than half the cost of replacing it, it makes economic sense to replace the defective parts. However, if the furnace is older than 15 years, it would be better to replace it with a newer heating system.

Your Furnace is Working Less Efficiently 

Have you had to tinker with your thermostat settings more often than you used to? Does your home seem to be heated unevenly, with some rooms being warmer than others are? Although your heating system may just be losing power or the duct system may be struggling to distribute heat, it is also likely that your furnace is working less efficiently than it used to. If it is a relatively new system and the repair cost does not exceed half the replacement costs, contact an HVAC contractor in White Bear Lake. Our team of professionals will come out for heating maintenance. However, if the furnace is advanced in age, repairing it would only be postponing the inevitable. Replace it instead.
A healthy and well-functioning furnace is crucial to living through the cold months of winter. When contemplating “should I repair or replace my furnace?”, use this guide to help you make the best decision. McQuillan Bros, MN furnace installation experts, are happy to help. Contact us today for honest work at fair prices.

Have You Scheduled Your Seasonal HVAC Maintenance?

Have You Scheduled Your Seasonal HVAC Maintenance? - McQuillan Bros

Have You Scheduled Your Seasonal HVAC Maintenance with McQuillan Bros?

Seasonal HVAC maintenance is vital to ensuring that the system works efficiently and reliably while keeping energy costs minimal. However, some homeowners don’t know where to start in terms of seasonal HVAC maintenance, and the discussion below is aimed at helping you to know what needs to be done, when and by whom.

HVAC Maintenance and Safety Concerns

At McQuillan Bros, we are particularly concerned about two safety issues with regard to seasonal HVAC maintenance.

The first has to do with the problems which can result once your heating and cooling system isn’t properly maintained. For example, Blaine HVAC experts say it is easy for a crack to form on a furnace and remain undetected if annual maintenance isn’t performed on the heating system. Such a crack can leak carbon monoxide into your home, and your household may be in grave danger due to this toxic gas that is odorless. Furthermore, electric systems can short-circuit, and this can pose electrical fire risks to your home and family. Furnace installation MN technicians have seen many tragedies arising out of such electrical defects, so don’t let your home add to the statistics.

The second safety concern has to do with DIY attempts to maintain the HVAC system. Many homeowners don’t know where to draw the line between what they can do and what should strictly be left to a Blaine HVAC contractor. Some maintenance tasks, such as replacing air filters, are basic, and they can be performed by anyone, while other maintenance tasks, such as testing the controls of the HVAC system, are technical and can only be done safely by a professional. 

With McQuillan Bros as your HVAC service partner, you will know what you can or cannot do while keeping your heating and cooling system working at its best.

Seasonal HVAC Maintenance Tasks for Professionals

A Blaine heating and cooling professional will perform the following seasonal HVAC maintenance tasks to prepare the system for either the heating or cooling season ahead:

  • Inspecting all electrical terminals, wires, and connections to ensure none are loose or corroded.
  • Lubricating the moving parts so that they can move effortlessly and without using a lot of energy.
  • Checking the refrigerant level to ensure it is optimal
  • Inspecting and cleaning all the major components in addition to ensuring they are damage-free
  • Ensuring that the airflow within the components meets manufacturer specifications for efficiency
  • Testing the controls to ensure they are working as they should
  • Checking the thermostat for accuracy
  • Checking the coils to ensure grime accumulation doesn’t impede heat transfer
  • Clearing the condensate drain to avoid water damage or system shutdown once water stagnates in the line.

Our McQuillan Bros team visits Minneapolis homes armed with an extensive maintenance checklist. We also inform our clients about the tasks they can attend to in-between our visits.

Homeowner Seasonal HVAC Maintenance Tasks

Here are some maintenance tasks that you can perform to ensure that your HVAC system works properly all-year-round.

  • Checking and replacing the air filter. The energy consumption of your unit can increase by up to 60% with a dirty filter. The filter plays a big role in maintaining the indoor air quality, as well as the efficiency of the HVAC system. We recommend checking your air filter monthly.
  • Sealing air leaks. Any leak in your home allows the conditioned air to escape to the outside. That means that your HVAC system will work a lot harder than it should to maintain ideal conditions inside your home. Placerville plumbing and heating professionals, therefore, recommend that you periodically check the house envelop for leaks and seal those leaks in order to get the best from your HVAC system.
  • Keep the unit clean. It is also a good idea to wipe down your HVAC system periodically. This will ensure that any accumulation of dust and grime can be removed in a timely manner. Otherwise, heat exchange may be tampered with, and the efficiency of your unit will be compromised. Not to mention its durability (as it will suffer premature wear and tear).

If you haven’t scheduled your seasonal HVAC maintenance, now is the time to do so. Contact McQuillan Bros today for a boiler tune-up, furnace tune-up. One of our experienced HVAC technicians will make sure your HVAC system is ready for the new season.

Should I Replace My Boiler?

should I replace my boiler St Paul

Should I Replace My Boiler

At McQuillan Bros, we often get asked by Minneapolis homeowners if they should or shouldn’t replace their boiler. For this reason, we have decided to put together the guide below so that every Minnesota homeowner can decide if replacing their boiler is a good decision. 

What You Need for the Calculation

To determine whether you will save money when you replace your boiler with a more efficient one, you need two pieces of information.

First, Minneapolis heating and cooling experts recommend that you contact your utility company and find out how much energy (in kilowatt-hours) your current boiler uses each year. This information may also be available on your energy bill, but it may be difficult to understand. So, your best bet is to ask the utility company for this information.

Secondly, you need to find out the efficiency of your boiler. This efficiency rating is normally indicated on the tag having the model and make of the boiler. Our HVAC technicians are quick to note that as the years roll by, the boiler’s efficiency is likely to drop further, especially if the appliance hasn’t been well maintained.

For example, a boiler rated at 80% efficiency by the manufacturer may have dropped several percentage points over the years.

Will I Save If I Replace the Boiler?

To find out if you’ll save after replacing your boiler, Gilmore Heating and Air, a heating company in Sacramento, share exactly how you can find out. Do some calculations using the efficiency and annual energy use information you collected earlier. Follow the steps below.

Calculate How Much Heat Your Boiler Produces Annually

Minneapolis heating experts say this is easy to do as you just have to multiply the kilowatt-hours of energy consumed each year by the boiler’s efficiency rating. Then you divide this by 100. For example, if your boiler uses 15,000kWh of natural gas each year and the boiler is rated 78% efficiency, your calculation will be 15,000×0.78 to give you 11,700 units of heat to warm your home.

Calculate How Much Energy a New Boiler Would Produce Annually

To get this figure, take the units of heat calculated earlier and multiply that number by the efficiency of the new boiler you wish to buy. For example, if the new boiler has a 90% efficiency rating, you will multiply 11700×0.90 to give you 10,530 kWh of energy.

Find Out How Much Less Gas You Will Need Once the New Boiler Is Installed

For this, Minneapolis HVAC contractors say you subtract the new boiler’s energy from the energy used by the old boiler. In our example, this will be 15,000-10,530 to give you a difference of 4,470 units of energy.

Find Out the Cost of the Energy You Save

This simply requires you to multiply the number of kWh by the unit cost of each kWh. For example, 4470x$0.437. This will give you a saving of $195 each year.

The national average cost for buying a boiler in the U.S. is $5,596. So, you would need about 28 years to recoup your investment. Is it worth it, in this case, to invest in a new boiler? The numbers don’t say so. However, if you use a lot more energy each year and the efficiency of your boiler is lower than what we used as an example, the figures will play out differently, and you may save by upgrading to an energy-efficient boiler.

Should I Replace My Boiler or Repair It?

Remember, everyone’s household is different, so we recommend going over the numbers with trained professionals. Not ready to upgrade your boiler? You can also compare the cost of boiler repair or boiler maintenance. If you’re unsure if you need a boiler repair or a boiler replacement, contact McQuillan Bros. Our team is always happy to help. We always have prompt arrivals, meticulous cleanup, and dependable follow-through.Ultimately, the decision to replace your boiler is up to you. Run the numbers, talk to a Minneapolis HVAC contractor, and contact McQuillan Bros.

New Year’s Heating Maintenance Solutions

New Year's Heating Maintenance Solutions

Resolve to Have a Warm & Stress-Free Winter

With a new year just a stone’s throw away, there’s no place in your schedule for heating breakdowns or rising energy bills. Before you don your party hat and ring in 2018, make plans to have your heating system or boiler inspected, lubed and cleaned. According to the Environmental Protection Agency, frequent filter changes and routine HVAC tune-ups prevent unhealthy dust buildup and can improve heating efficiency and comfort, year round.

3 New Year’s Resolutions for Home & HVAC Health

A fresh, new year brings inspiration, motivation and a unique set of goals and challenges. Once you’ve settled on your personal resolutions, consider extending your objectives to include home maintenance, comfort and safety. Remember, your home’s mechanical systems need attention as much as you need self-care.

  1. Commit to HVAC fitness. A “fit” heating system receives twice-annual inspections, including safety checkups, thermostat calibration and cleaning of hard-worked components. After holiday guests depart, it’s a perfect time to have McQuillan Bros Twin City heating professionals perform comprehensive maintenance on your furnace, heat pump, hot water boiler or steam boiler. Regular HVAC care also reduces the chance of a catastrophic equipment failure since technicians keep tabs on the inner workings of your system.
  2. Tighten your purse strings. If the post-holiday slump finds you recovering from overspending or revamping your budget, a few simple steps can help you lower year-round energy costs. The Department of Energy recommends installing a programmable or “smart” thermostat to save on heating and cooling costs, switching to energy-saving LED bulbs and lowering your water heater’s temperature. And don’t forget to take advantage of natural warmth during winter by choosing window treatments that let the sun shine in.
  3. Learn something new. Life is more rewarding when you pursue knowledge and personal growth. This year, make it your mission to better understand your home’s heating, cooling and plumbing system. McQuillan Bros’ friendly, knowledgeable HVAC technicians can explain the ins and outs of your steam boiler, furnace or heat pump. Using helpful videos and new equipment training sessions, our highly trained team educates and empowers homeowners to make safe and economical indoor comfort decisions. The more you know, the better equipped you are to choose a new heating system when a breakdown occurs.

McQuillan Bros Home Care Club: Your Answer to 2018 Comfort

Start off the new year by investing in Minnesota’s Original Home Care Club and enjoy:

  • Reduced repair costs
  • Fewer emergencies
  • Longer equipment life
  • Lower utility bills
  • Improved indoor comfort & HVAC performance
  • Routine safety inspections

The Home Care Club is an affordable membership that quickly pays for itself and delivers the peace of mind every Washington, Hennepin and Ramsey County property owner needs. Trust McQuillan Bros Plumbing, Heating & AC to protect your house and keep your mechanical systems performing efficiently and effectively, month in and month out. Join the Club now: 651.237.5097.
Wishing you a happy, healthy New Year from the McQuillan Bros family!